|
#1
07-08-2007, 02:48 PM
Hummer Guru
Join Date: Oct 2005
Location: Charlotte, NC
Posts: 2,767
Now tell me I can't keep the sonofabitch cool....
As many of you know, I installed a supercharger a few months ago. I put an 2 core aluminum radiator with dual electric fans on it.
I put a larger intercooler in front of the condensor and moved the transmission cooler immediately behind the grille.
Problem is, when I got stuck in traffic, the truck ran hot. The dual electric fans were 4600 cfm between the two of them but they were not built into a "shroud" like the new ones. They were separate fans.
The computer was programmed to go into closed loop at 160 degrees but I'm still running the stock thermostat (195). Lingenfelter has sent me 2 thermostats but they both wrong. Apparently they used an '04 thermostat housing on my .03
Soooooo, I bought some 6000 cfm fans with a shrouds, moved the transmission cooler under the truck and used one of the electric fans that were on the radiator, underneath blowing on the trans cooler.
This clears up the space in the grille. The oil cooler is underneath at the moment but hopefully all this will work. It was only in the 70's yesterday but when I punched it for a good 1/2 mile or so, nothing got warm.
We'll see.
Here's the radiator with the new fans...
Intercooler
Fan underneath
Side view...
Hopefully there's no issues right now with the fan being below the guard but eventually I will buy one of the B&M coolers with fan setup to go above the guard.
As Tim says, it's been so long since I've been off road, it's a pavement princess...
#3
07-08-2007, 05:24 PM
Hummer Guru
Join Date: Sep 2006
Location: Europe, Belgium, Waregem
Posts: 5,280
Re: Now tell me I can't keep the sonofabitch cool....
Sweet !
__________________
http://hummertruckworld.tenmagazines...lery.ten?id=29
MY TRUCK : NO !
MY DOG : MAYBE
MY WIFE : YES
#4
07-09-2007, 03:28 AM
Hummer Authority
Join Date: Nov 2004
Location: Little Rock, Arkansas
Posts: 1,784
Re: Now tell me I can't keep the sonofabitch cool....
Should work good for you Orange.
Good job!!!!!!
TAZ
__________________
05 H2 SUV cus. paint, Magnuson SC 6/12lb boost, cowl hood scoop, 12" dash touchscreen, GM elec. fans, HPTuners.com tuning soft., Dynatech headers dual catback exhaust Jet Hot chrome front to back Flowmaster Super 40's, Diamo 8 Karat rims & 325X60-20" Toyo, 4 OEM Captain seats Katzkins leather, rear console computer inside running all AV/NAV etc., Infinity component system 3 amps Tsunami Caps, rear flip down 12" monitor, headrest monitors, overhead console boost, fuel pressure, & A/F ratio gauges
#5
07-09-2007, 02:58 PM
Hummer Veteran
Join Date: May 2007
Location: Rolling Meadows, IL
Posts: 238
Re: Now tell me I can't keep the sonofabitch cool....
Soooooo, I bought some 6000 cfm fans with a shrouds, moved the transmission cooler under the truck and used one of the electric fans that were on the radiator, underneath blowing on the trans cooler.
How was the install of the fan? easy? What brand did you use for the fan?
I am planning on taking off the belt driven fan and replace with the electric fan and wndering about the wiring and installation.
Thanks and your truck looks good!!
#6
07-09-2007, 06:07 PM
Hummer Guru
Join Date: Oct 2005
Location: Charlotte, NC
Posts: 2,767
Re: Now tell me I can't keep the sonofabitch cool....
Answered your PM.
Hope that helps.
Mark
«
Previous Thread
|
Next Thread
»
Thread Tools
Search this Thread
Display Modes
Posting Rules
All times are GMT +1. The time now is 06:45 PM.
Linear Mode
