K&N installed! With pics!

[FLYINGBADGER2006]

I purchased my K&N on ebay for $216.00. Install was no problem. Took it out for a spin after I did the install and all went fine. No rattling, no abnormal engine noise. I hope to see a slight improvent on performance and gas milage.
I am looking into Magnaflows or Borlas for a cat-back exhaust in the near future.

[FLYINGBADGER2006]

and heres another.

[First Hummer]

<BLOCKQUOTE class="ip-ubbcode-quote"><div class="ip-ubbcode-quote-title">quote:</div><div class="ip-ubbcode-quote-content">Originally posted by FLYINGBADGER2006:
and heres another. </div></BLOCKQUOTE>

Nice Install Fly looks so sweet that mine will be here Thursday.

[boulderhummer]

engine light come on yet??

[FLYINGBADGER2006]

another pic.

[BB]

flyingbadger, it looks like coolant is leaking from the radiator pressure cap. Recently, I noticed the same thing with my H3, but not that much. Does anyone have the same trouble ? and does anyone know what's wrong with ?

[ChevyHighPerformance]

Originally Posted by BB

flyingbadger, it looks like coolant is leaking from the radiator pressure cap. Recently, I noticed the same thing with my H3, but not that much. Does anyone have the same trouble ? and does anyone know what's wrong with ?

I just noticed mine, yesterday. There wasn't much though.

[First Hummer]

<BLOCKQUOTE class="ip-ubbcode-quote"><div class="ip-ubbcode-quote-title">quote:</div><div class="ip-ubbcode-quote-content">Originally posted by FLYINGBADGER2006:
Well I know this much. K&N has been around for a long, long time and their products are race and road tested proven. I think the K&N allows alot more air intake, which some of that air is cold air could include engine radiant heat. When the hood comes down the "L" shaped wall that separates the air filter from the engine makes a box like compartment. The K&N also allows forced air from the front, and through the grille. I never seen a Volant up close and personal. But right off it looks cool and looks very enhancing to the performance to the air intake. Then I say, It looks just as restricting as the stock air intake. The stock intake is in a confind box like shape, as does the Volant. Grant it the stock air intake has baffles or a a resinator which distrupts the normal air flow to the intake manifold. I know the K&N and Volant are both better products than the stock intake. I know the Volant is more expensive and looks more astheticly better than just the K&N tube and a K&N filter. But its my opinon that the Volant looks like it makes the air harder to injest in that tight space and though it may block out hot engine air, it probably would restrict the cold air too. Versus the K&N which would allow more and all air to flow more easily. Which thats what we want is more colder unrestricting air.
I hope this helps. </div></BLOCKQUOTE>

Hey Fly,just a FYI check the bolt that holds the bracket in place on the intake.Mine fell off somehow must have loosened up somewhere along the way.

[hmrlvr]

flyingbadger, is there a cover for the K&N aircharger you installed? I saw a Volant on another thread with a cover. Apparently the cover will force the system to pull cool air from outside the vehicle instead of warm air from under the hood. I know you have a K&N but will the cooler air increase the HP more than the warmer air? Anyone have any feedback please let me know. I'm ready to order one of them and am trying to decide. Thanks

[RubHer Yellow Ducky]

hmrlvr vbmenu_register("postmenu_107117", true);
Hummer Expert
Join Date: Aug 2005
Location: Redondo Beach CA
Posts: 656




flyingbadger, is there a cover for the K&N aircharger you installed? I saw a Volant on another thread with a cover. Apparently the cover will force the system to pull cool air from outside the vehicle instead of warm air from under the hood. I know you have a K&N but will the cooler air increase the HP more than the warmer air? Anyone have any feedback please let me know. I'm ready to order one of them and am trying to decide. Thanks

PLEASE answer a question for me (this is to all who converted air intake systems)
The factory system that comes with the H-3 already draws cool air from the right fender area, NOT FROM UNDER THE HOOD. In what way, how, explain, is the effect of the other systems besides leaving your wallet $150 to $350 dollars thinner? I'm not interested in the sound that it makes but do you get a HP gain? If you do , HOW?

RYD

[H3.007]

Hey Ducky,

There isn't a cover for the K&N that I am aware of. I think the principle is that it allows more air flow as opposed to the more restrictive factory setup. I am not sur ehow the Volant system works but it appears to feed from the factory air inlet. if this is the case, the Volant is still a restircted airflow - but I could be wrong as I have the K&N.

I did have some concern about the amount of hot air that could get into the filter over the K&N shield wall. However, it only make sense that when the vehicle is moving, the majority of the hot air will be pushed backward, away from the filter and out of the engine compartment through void venting and the such. However, I did take the precaution of buying pipe insulation (used in home plumbing applications- about $4 for a large package) and I lined the entire shield with it. The insulation is presplit and I used strips of black duck tape for further insurance against the insulation coming loose and landing on something hot or getting caught in a pully. I also figure that this will further dampen the resonance and any vibrations that may occurr.

Also, I can not tell you the specific horsepower increase but damn does it get to 80 MPH a lot quicker than it did. Mid range response is also quicker and it certainly has more power in the high end. The only downer is, again, the resonance noise when you hit the upper end. I am workign on some ideas to reduce that without ending up back to square one so I will post the results if my idea(s) are succesful. It also appears that my GPM has increased but I won't know until I hit the half-tank mark.

Hope this helps!
Chris

[ChevyHighPerformance]

Originally Posted by H3.007

Hey Ducky,

There isn't a cover for the K&N that I am aware of. I think the principle is that it allows more air flow as opposed to the more restrictive factory setup. I am not sur ehow the Volant system works but it appears to feed from the factory air inlet. if this is the case, the Volant is still a restircted airflow - but I could be wrong as I have the K&N.

I did have some concern about the amount of hot air that could get into the filter over the K&N shield wall. However, it only make sense that when the vehicle is moving, the majority of the hot air will be pushed backward, away from the filter and out of the engine compartment through void venting and the such. However, I did take the precaution of buying pipe insulation (used in home plumbing applications- about $4 for a large package) and I lined the entire shield with it. The insulation is presplit and I used strips of black duck tape for further insurance against the insulation coming loose and landing on something hot or getting caught in a pully. I also figure that this will further dampen the resonance and any vibrations that may occurr.

Also, I can not tell you the specific horsepower increase but damn does it get to 80 MPH a lot quicker than it did. Mid range response is also quicker and it certainly has more power in the high end. The only downer is, again, the resonance noise when you hit the upper end. I am workign on some ideas to reduce that without ending up back to square one so I will post the results if my idea(s) are succesful. It also appears that my GPM has increased but I won't know until I hit the half-tank mark.

Hope this helps!
Chris

WhiteH3 posted some dyno sheets a while ago for his K&N. I think his was one of the first and was tested by K&N. From memory, his increase was about 18ish HP in 3rd gear at the wheels. The only mod was an exhaust (Magnaflow perhaps).

[RubHer Yellow Ducky]

WhiteH3 posted some dyno sheets a while ago for his K&N. I think his was one of the first and was tested by K&N. From memory, his increase was about 18ish HP in 3rd gear at the wheels. The only mod was an exhaust (Magnaflow perhaps).

THE ONLY MOD WAS A PERFORMANCE EXHAUST...

AH! that only mod is a BIG mod.
as i read over this posts you all are assuming the aftermarket (k&n, others) increase HP by possibly vortexing the air, and / or cooling the air, YES???

As I read the lit on the k&n and others they take about the cooler air they are allowing into the system, unlike the factory system. Again the H-3 uses cooler air so please inform me again what i am missing...
THANKS

RYD

[ChevyHighPerformance]

<BLOCKQUOTE class="ip-ubbcode-quote"><div class="ip-ubbcode-quote-title">quote:</div><div class="ip-ubbcode-quote-content">Originally posted by JohnB.GWU.:
why does the tube's diameter decrease at the filter.

according to the commericals, is that really a precision engineered tube or bottle neck restriction to increase velocity or some bs? </div></BLOCKQUOTE>

This is where the mass air sensor is transplanted from the stock air box base to this area. The internal cross sectional areas have to be the same for proper air flow rate measurements.

[Captain Steve]

I installed the AirRaid system...179 bucks. Great sound and great acceleration. No engine light problem. Did finnally get it up to 105 on a long strait away. I thought there was a governor

[First Hummer]

I just got done installing mine last night.Pretty easy install didnt take me long maybe 1 hour.I didnt get any check engine light when I started it up so thats good.I did get the gaskets backwards at first,but then Brain started to function again.I have the SMA exhaust already so maybe ill see a little more giddy up.

[hmrlvr]

Thanks for the info, much appreciated.

[FLYINGBADGER2006]

How much did you pay for the SMA exhaust?

[MyxH3]

Looks like a clean fitment. Let us know how it goes

[Bling]

<BLOCKQUOTE class="ip-ubbcode-quote"><div class="ip-ubbcode-quote-title">quote:</div><div class="ip-ubbcode-quote-content">Originally posted by Captain Steve:
I installed the AirRaid system...179 bucks. Great sound and great acceleration. No engine light problem. Did finnally get it up to 105 on a long strait away. I thought there was a governor </div></BLOCKQUOTE>

I got a freak'n ticket (warning) today and have to remove my K&N and get police officer to sign off. Guess these are illegal in CA.