Transmission Temperature

[VegasGuy]

Originally Posted by HummerMann

I've noticed that driving in the 98F temperatures we've been having my transmission has been running at about 190. How does your transmission temperature run in hot weather?

It was 103 in Vegas today. My transmission temp was about 190 also.

[tcalz06]

I installed the larger cooler mentioned on this site right after I purchased my 05.
In AZ with temps at 112 my tranny temp barely reads 150.

The cooler seems to work great. I've had it on for about 8000 miles so far

[jmanley]

So I've asked this question a few times. I was in the mountains in February, and it was -20F and the tranny, while pulling a trailer with 4 mountain snowmobiles on it (500# each - probably 1.5 tons total weight with trailer) and I was running trans temps as hot as 225-230F. Much too hot in my opinion, but when I talked to the dealer, they *claim* that this is normal and that it could go as high as 250F.

In my racing experience, anything under 200F is good, anything over 210F is bad, so it concerns me when it hits 225F and I can *smell* it!

Jay

[jmanley]

Originally Posted by tcalz06

I installed the larger cooler mentioned on this site right after I purchased my 05.
In AZ with temps at 112 my tranny temp barely reads 150.

The cooler seems to work great. I've had it on for about 8000 miles so far

What cooler did you buy, where did you put it, and how did you route the lines? Did you have a factory cooler as well?

[NJ H2]

Most everyone installs the Tru-Cool Tranny Cooler. I did it and like mentioned run 150ish. Last week I pulled an empty 24 ft Haulmark Trailer about 3500 LBS and ran about 190.
There is tons of info on this forum about it.
IMO this is 1 of the best MODs for the money you can do.
Here's the link to the search for "Tru-Cool"

http://www.elcovaforums.com/forums/s...earchid=264624

[VegasGuy]

Originally Posted by NJ H2

Here's the link to the search for "Tru-Cool"

http://www.elcovaforums.com/forums/s...earchid=264613

FYI: No matches.

[NJ H2]

Originally Posted by VegasGuy

FYI: No matches.

Funny ... I checked it after I put the link in. Anyway I edited it and put the link in again. It works now but if not just search "Tru-Cool"

http://www.elcovaforums.com/forums/s...earchid=264624

[H2illBilly]

The Tru Cool tranny cooler is worth every penny. I installed it about 6 months ago and have never gone over 150 deg. If your not worried about the temp at least bypass the radiator. It's a tight fit but worth the headache.

[tcalz06]

Originally Posted by NJ H2

Most everyone installs the Tru-Cool Tranny Cooler. I did it and like mentioned run 150ish. Last week I pulled an empty 24 ft Haulmark Trailer about 3500 LBS and ran about 190.
There is tons of info on this forum about it.
IMO this is 1 of the best MODs for the money you can do.
Here's the link to the search for "Tru-Cool"

http://www.elcovaforums.com/forums/s...earchid=264624

Yep, Tha'ts what I used and used the write up on here for the install.
I just completed my second 3200 mile road trip with it from AZ to Illinois
works great at 116 degree outside temps running 80 up some big ass Hills through northern AZ

[SmokeyJoe]

No Photos sorry,

I installed the cooler like this.

I removed the factory cooler the front of radiator. Drilled out the rivets from the bracket so I could put them back on later.
On the passenger side of the radiator is where the stock lines are for the internal cooler, remove lines and install fittings and place a hose between them to bypass creating a U shape.
You will have to cut the bottom line going back into the transmission, put a piece of hose on it and run it to the cooler.
The output line cut the line and run the hose to the other side of the cooler.

Any cut lines I used a pipe cutter then double flanged them to make a mushroom.

The only problem I have run into is the positioning of this huge cooler. Right now its hard to close the hood because it is hitting the 2 bolts for the bottom brackets. I will have to reposition this later.

So how does it work, maybe to good. I drove to work today (55F) and the temp never broke 130F, and most of the time on the highway (80MPH) it stayed around 110F. I am not sure if this is ideal or not, as I just went by the recommedations here. So if anybody knows about this please let me know?????

While doing this I changed the filter and fluid. After I changed the filter, I took the upper radiator transmission line off and put about 5" of rubber hose on it. Then clamped it to a big bucket. I had my wife start the H2 up, and as it pumped the fluid out I poured new fluid in until it ran out cherry red.

So while I was at it I decided to change all of the fluids- radiator, diffs & trans case.

[giant h2]

Anyone try a fan on the factory cooler??? I have been told that a larger cooler will affect the AC.